Open Library - открытая библиотека учебной информации

Открытая библиотека для школьников и студентов. Лекции, конспекты и учебные материалы по всем научным направлениям.

Категории

Строительство Brake Disc
просмотров - 293

BRAKES 12-21

Brake Disc Removal

• Remove the wheel (see Front Wheel Rear Wheel Re­moval in the Wheels/Tires chapter).

• Unscrew the mounting Allen bolts [A], and take off the disc [B].

Brake Disc Installation

• Install the brake disc on the wheel so that the marked side [A] faces out.

• Tighten the mounting Allen bolts.

Torque - Brake Disc Mounting Bolts: 23 N·m (2.3 kgf·m, 16.5 ft·lb)

Brake Disc Wear

• Measure the thickness of the disc at the point where it has worn the most.

• Replace the disc [A] if it has worn past the service limit.

Measuring Area [B]

Disc Thickness Standard: 4.8 ~ 5.1 mm (0.19 ~ 0.20 in.)

Service Limit: 4.5 mm (0.18 in.)

Brake Disc Warp

• Jack up the motorcycle so that the front wheel is off the ground.

Special Tool - Jack: 57001-1238

• Turn the handlebar fully to one side.

• Set up a dial gauge against the disc [A] as shown and measure disc runout.

• Turn [B] the wheel by hand.

If runout exceeds the service limit, replace the disc.

Disc Runout Standard: Less than 0.1 mm (0.004 in.)

Service Limit: 0.2 mm (0.008 in.)

12-22 BRAKES


Читайте также


  • - REAR WHEEL AND BRAKE DISC CHAS

    CHASSIS REAR WHEEL AND BRAKE DISC CHAS J-5 FRONT WHEEL AND BRAKE DISC CHAS 5. Check: • Wheel static balance ************************************************************ Checking steps: Turn the wheel so that it comes to each point as shown. Check that the wheel is at rest at each point. If not, readjust the front wheel static balance. ************************************************************ REAR WHEEL AND BRAKE DISC ... [читать подробенее]


  • - REAR WHEEL AND BRAKE DISC CHAS

    CHASSIS REAR WHEEL AND BRAKE DISC CHAS J-5 FRONT WHEEL AND BRAKE DISC CHAS 5. Check: • Wheel static balance ************************************************************ Checking steps: Turn the wheel so that it comes to each point as shown. Check that the wheel is at rest at each point. If not, readjust the front wheel static balance. ************************************************************ REAR WHEEL AND BRAKE DISC ... [читать подробенее]


  • - FRONT WHEEL AND BRAKE DISC CHAS

    FRONT WHEEL DISASSEMBLY   Order   Job name/Part name   Quantity   Remarks   Front wheel disassembly Oil Seal Bearing Spacer Bearing     Remove the parts in order     Refer to “FRONT WHEEL DISASSEMBLY/ASSEMBLY” section.   Reverse the removal procedure for installation. 23Nm(2,3m•kg) 23 Nm (2,3 m•kg) ... [читать подробенее]


  • - FRONT WHEEL AND BRAKE DISC CHAS

    J-3 Mm Do not attempt to straighten a bent axle. FRONT WHEEL INSPECTION Handle the wheel with care not to damage the brake disc. If the brake disc is damaged, replace. 1. Inspect: • Front wheel axle (by rolling it on a flat surface) Bends —( Replace sWARNING Wheel axle-bending limit: 2. Inspect: • Front tyre Wear/damage —( Replace: Refer to “TYRE INSPECTION” in CHAPTER 3. • Front wheel Refer to... [читать подробенее]


  • - FRONT WHEEL AND BRAKE DISC

    FRONT WHEEL AND BRAKE DISC CHAS J-2 FRONT WHEEL AND BRAKE DISC CHAS Gasoline (fuel) and its vapours are highly flamma- ble and explosive. Keep away from sparks, ciga- rettes, flames or any other sources of ignition Any error in checking for fuel leaks can cause fire or an explosion. INSPECTION OF THE FUEL COCK I-5 CARBURETTOR CARB 1. Remove: • Seat and compartment Refer to the “COVER AND PANEL” section in CHAPTER 3. 2.... [читать подробенее]


  • - Brake Disc

    BRAKES 12-21 Brake Disc Removal • Remove the wheel (see Front Wheel Rear Wheel Re­moval in the Wheels/Tires chapter). • Unscrew the mounting Allen bolts [A], and take off the disc [B]. Brake Disc Installation • Install the brake disc on the wheel so that the marked side [A] faces out. • Tighten the mounting Allen bolts. Torque - Brake Disc Mounting Bolts: 23 N·m (2.3 kgf·m, 16.5 ft·lb) Brake Disc Wear • Measure the thickness of the disc at the... [читать подробенее]